Sciact
  • EN
  • RU

Hydrothermal hydrolysis of microcrystalline cellulose from birch wood catalyzed by Al2O3‑B2O3 mixed oxides Научная публикация

Журнал Wood Science and Technology
ISSN: 0043-7719 , E-ISSN: 1432-5225
Вых. Данные Год: 2022, Том: 56, Номер: 2, Страницы: 437-457 Страниц : 21 DOI: 10.1007/s00226-022-01363-4
Авторы Tarabanko Nikolay 1 , Baryshnikov Sergey V. 1 , Kazachenko Aleksandr S. 1,2 , Miroshnikova Angelina V. 1,2 , Skripnikov Andrey M. 1,2 , Lavrenov Alexander V. 3 , Taran Oxana P. 1,2 , Kuznetsov Boris N. 1,2
Организации
1 Institute of Chemistry and Chemical Technology SB RAS, FRC KSC SB RAS
2 Siberian Federal University
3 Center of New Chemical Technologies BIC SB RAS

Информация о финансировании (1)

1 Российский научный фонд 21-13-00250

Реферат: Hydrothermal transformation of microcrystalline cellulose (isolated from birch wood) under the influence of Al2O3- B2O3 mixed oxide solid acid catalysts was studied at temperatures of 180 and 215 °C (catalyst and cellulose were mix-milled in an AGO-2 planetary mill). At 180 °C, during the first hour, the average accumulation rates of glucose and 5 hydroxymethylfurfural attain 1030 and 320 mg of product per gram catalyst per hour, respectively. This activity exceeds typical values for sulfonated carbons bearing a similar concentration of acid groups (2.5 times faster glucose accumulation, 4.4 times faster 5-hydroxymethylfurfural accumulation). However, rapid accumulation of unhydrolyzed cellooligosaccharides in the reaction solution causes inhibition of the hydrolysis process after the first hour, probably via oligosaccharide chemisorption on the catalytically active acid sites, which leads to their deactivation. After the process at 180 °C, the catalysts can be washed with water and used again without significant loss of the catalytic performance; after four consecutive runs with the same catalyst, the combined yield of glucose, 5-hydroxymethylfurfural and furfural decreases by 15% compared with the first run. While the catalysts show considerable activity toward acid conversion of glucose into 5-hydroxymethyl furfural, the commonly observed next stage of such conversion into levulinic acid notably does not occur at 180 °C and proceeds at 215 °C.
Библиографическая ссылка: Tarabanko N. , Baryshnikov S.V. , Kazachenko A.S. , Miroshnikova A.V. , Skripnikov A.M. , Lavrenov A.V. , Taran O.P. , Kuznetsov B.N.
Hydrothermal hydrolysis of microcrystalline cellulose from birch wood catalyzed by Al2O3‑B2O3 mixed oxides
Wood Science and Technology. 2022. V.56. N2. P.437-457. DOI: 10.1007/s00226-022-01363-4 WOS Scopus РИНЦ OpenAlex
Даты:
Поступила в редакцию: 29 апр. 2021 г.
Принята к публикации: 7 февр. 2022 г.
Опубликована в печати: 1 мар. 2022 г.
Идентификаторы БД:
Web of science: WOS:000762888800001
Scopus: 2-s2.0-85125422136
РИНЦ: 48186799
OpenAlex: W4214641498
Цитирование в БД:
БД Цитирований
Scopus 22
Web of science 19
OpenAlex 23
Альметрики: